Are you a fabric scrap saver? Do you have dreams of using them up for something? Yes, of course you are. Maybe you don't save them all but, you do save pieces big enough to use for something special. My rule is if its big enough to use for a pocket, it gets saved.

I've discovered the best fabric-busting project of all time. It uses all your fabric scraps up. Okay, it doesn't technically "use" them but, it does put them to use. You're going to sew a simple floor cushion and store all your scraps inside! ​

​You'll want to plow through that list of sewing projects so you can cut into fabric and have more scraps to fill the floor cushion. Whew! Trust me, I'm speaking from experience. ;)

Cozy Meets Functional

The floor cushion itself is not a good scrap buster. You might need to buy fabric to make it. But, it'll free up space in your sewing area, I promise. 

I was lucky enough to have leftover grey chenille from my pop-up trailer makeover, so I used that. You'll want to use an upholstery-weight fabric or something similar. This cushion is going to take a beating. 

If you have upholstery thread, you can use it here. If you don't, good ole polyester thread works fine. This whole project takes 2hrs give or take. It's a quick sew and gives a huge reward! 

If you're still on the fence about making one, think ottoman, pet bed, kid's seat, etc.

My cat claims it as his bed when my son isn't using it for his feet. It gets carried from room to room and makes a great coffee table game chair as well. I'm surprised it hasn't been involved in a pillow fight yet.

Supply List:

• 2.5 yards upholstery fabric or similar weight fabric (you'll have a little bit left over) 

• Thread

• Clips or pins

• 14" Zipper 

• That huge pile of fabric scraps

• Sewing machine

• Scissors, a ruler, a marking tool, etc. 

Wash your fabric if you want. I didn't. When I need to wash it in the future, it'll shrink a little and be fine. 

You're going to sew a large cube and fill it with your fabric scraps. Hooray!
​
1. Cut ​2, 21" squares. Cut 4 rectangles measuring 15.5" by 21". Serge or zigzag over the raw edges. Upholstery fabric loves to fray. 

2. Clip or pin the rectangles together along the short sides, right sides together. You're making a loop. Sew up the short sides using 1/2" seam allowances, backstitching at the beginning and ends.

3. Lay one square right side up on your table. Clip one side of the loop you just made from the rectangles, onto the square, RST. It's easiest to clip the corners of the square to the side seams first. Then, ease the side seams in. Your upholstery fabric might have some stretch in it but, you tell it who's boss!
​
​If you don't want to insert a zipper, sew along the edge using 1/2" seam allowance.

4. Here's where you'll insert your zipper if you want one. This is a little different than inserting a zipper into a bag so, bear with me. 

Clip/pin one side of the zipper to a rectangle edge. Sew the zipper with a zipper foot. 
Open the zipper and clip the zipper tape to the square bottom edge. Sew using the zipper foot. You might have to sew one side of the zipper tape facing down which feels awkward but is totally fine.

Switch back to your regular sewing foot to sew around the whole square. Start at one end of the zipper and end at the other end of the zipper. Open and close the zipper to make sure it's lined up, if it isn't smooth, unpick one side and resew it. 

*It's easier to sew with the flat piece down and move the rectangles out of the way as you sew.

To get the seam and zipper area to match up nicely, sew an extra 1/8" inside the zipper seam allowance when you get to the zipper.

​It's a little trick that's used when inserting invisible zippers. 

5. Now that the hardest part is over, it's time to sew the top square on. Clip the top the same way you did with the bottom square. Start with the corners first, then clip the sides. Sew all around using a 1/2" seam allowance. 

This might look tricky but, take your time. Go slow and make sure you're only sewing over the 2 layers.

6. Turn the cushion right side out and pop out the corners. You don't have to worry about trimming the corners unless you want to. I left them alone. Press the seams open as well as you can. 
​

Ta-da! You've made a floor cushion, bean bag, floor pouf, or whatever you want to call it. You made one!

7. Stuff it with all those fabric scraps inside. It's very therapeutic. If it feels empty still, toss some extra yardage inside if you'd like. I had yards of fleece, minky, and faux fur from my baby gift making days and that really helped to fluff it up.

You can even fill it with those random pieces of interfacing you're probably saving.  ;) 

All that's left to do is use it. Who gets to use it first? The kids, your kitty, or you?

Read Below for Extra Tips:

• Use a long enough zipper to get your hand in and out. Originally, I used a tiny 6" zipper thinking I'd never need the scraps again. Haha!! It was quickly ripped out and replaced with a longer 14" one. It's fun and easy to add more scraps. And, if you need a pocket or other scrap-sized piece of fabric in the future, you can look through them easily. Dump everything out onto a table and sift through them all.

• If you have random pieces of heavy-weight fabrics, use them to make the cushion. Use a different piece for each side, top, and bottom. It'll give it an eclectic and lively look. Faux fur would be fun too!

You can make a set if you have buckets and buckets of scraps lying around. Oh, a set would be great for a kid’s room or game room as well. 

Now I'm off to tackle that sewing to-do list. I need more scraps!! 

So, are you ready to put all those scraps to use? Well, store them in a fun way at least. If you do, tag me on Instagram @sewingtothemoon so I can see them all.

Happy stuffing!
​Annette